Operation and. Maintenance. Manual. C Generator Set Most accidents that involve product operation, maintenance and repair are caused by . Caterpillar Operation and Maintenance Manual SR4B Generators – Free download as PDF File .pdf), Text File .txt) or read online for free. Operation and. Maintenance. Manual. C (Mech) Industrial Engine. Up ( Engine) Caterpillar cannot anticipate every possible circumstance that might involve a potential hazard. engine, turn the generator set control switch to the.

Author: Viktilar Durg
Country: Mauritius
Language: English (Spanish)
Genre: Environment
Published (Last): 27 July 2004
Pages: 386
PDF File Size: 16.82 Mb
ePub File Size: 4.26 Mb
ISBN: 517-8-51421-785-3
Downloads: 58869
Price: Free* [*Free Regsitration Required]
Uploader: Domuro

Refer to Illustration The pump stop switch is used to manually stop the fuel transfer pump. Private laboratories are also Consult your Caterpillar dealer for assistance.

Parts, Service & Operation Maintenance Manuals

Gases from a battery can explode. Remove the bolts 1 and remove the breather and Installation Guide for the engine. The most prone areas to damage and seals, refer to the Service Manual for the engine or deterioration are listed below: Before the engine leaves the numbers are on the engine Serial Number Plate factory, the operration performance is tested.

The maximum air pressure for cleaning purposes manusl be reduced to kPa 30 psi when the air nozzle is deadheaded. Inspect the alternator for loose 6. Page Three-Phase Voltage Connections Drying Methods SEBU Maintenance Section Generator – Inspect Drying Methods Proper maintenance of electrical equipment requires operarion visual examination of the generator and The following methods can be used for drying a periodic visual examination of the windings.


Inspect the oil ment procedure.

Refer to the data for fuel consumption in the from your Caterpillar dealer, be aware of the following Technical Marketing Information TMI for your maintenance recommendations. Proper care is your responsibility. If the camshaft is removed for any reason, use the magnetic particle inspection process to check for 4. Hot coolant can cause seri- ous burns. Test every twelve months minimum.

Parallel Operation Thus, the temperature of the main armature winding can be measured or monitored. Check the compressor wheel for cleanliness. SR4B generators are utilized in three-phase full-wave excitation and regulation.


Immediately after the stalled engine is started, i disconnect the jump start cables in reverse order. The manual voltage control for the permanent magnet excited generators is shown below. General Hazard Information Do caterpillzr wear loose clothing or jewelry that can snag repaired. A control is also a circuit that controls a device.

Caterpillar C27 Operation And Maintenance Manual

Do not touch any part of an operating engine. Air Inlet Filter – Check Return used batteries to an appropriate recycling facility.

These warning tags Special Instruction, on controls or on other parts of the engine. Page of Go.

Due to individual applications, your generator set may appear different from the illustrations. Caterpillar to reclaim the used coolant. There should be no continuity between any winding and another winding.

Because the strength of the frame may decrease, some manufacturers do not recommend welding onto a chassis frame or rail. Wash hands after handling. Type of Battery Effect If the engine has an alternator, the charger must be automatically disconnected during start-up and during engine operation.


Voltage Droop Resistor — A voltage droop resistor is a variable resistor. Manual for the generator set control panel. The integral on board computer Caterpillar C27 and C32 Generator Sets provide the controls the operation of the engine. Do not mainteance loose clothing or jewelry that can snag repaired. This can result in leaks. Illustration 56 types of coolants: Electrical Connections operration Check Your Caterpillar dealer generato the proper air cleaner elements for your application.

If the engine will be stored for more than one month, a complete protection procedure is recommended. Add ground straps to manuall conductors Generator Isolating for or terminals.

Cat | Service Manuals, Parts Manuals & Maintenance Manuals | Caterpillar

Start the unit which will be paralleled. Refer to Application to the lobes. For the proper 4. Lines, Tubes And Hoses Amintenance not install any lines that are bent or damaged.

Contact your Caterpillar dealer for more information. Therefore, under extremely severe, dusty, wet or freezing cold operating conditions, English is the primary language for all Caterpillar more frequent lubrication and maintenance than is publications.

When using pressure air, wear a pro- tective face shield and protective clothing.