Our John Deere Gator HPX 4X4 OEM Service Manual is a brand new original OEM (Original Equipment Manufacturer) manual for this machine. Tractor OEM. Find great deals for John Deere 6×4 Gator Technical Service Manual CD TMCD. Shop with confidence on eBay!. Find great deals for John Deere 4×2 / 6×4 Gator Workshop Repair Manual on CD. Shop with confidence on eBay!.

Author: Maugis Malagal
Country: Swaziland
Language: English (Spanish)
Genre: Marketing
Published (Last): 12 February 2005
Pages: 276
PDF File Size: 4.42 Mb
ePub File Size: 4.47 Mb
ISBN: 247-1-27219-860-5
Downloads: 93066
Price: Free* [*Free Regsitration Required]
Uploader: Kigagul

Service Engine Engine Warranty Maintenance Statement Maintenance, repair, or replacement of the emission control devices and systems on this engine, which are being done at the customers expense, may be performed by any non-road engine repair establishment or individual.

Allow engine to cool before servicing. Do not allow hose to contact bottom of reservoir or bend upwards out of the coolant. The engine and components will be hot if the engine has been running. DO NOT operate engine seevice air cleaner element and rubber dust unloading valve installed.

Add coolant mixture at bleed screw port B until coolant runs out. Tighten bleed screw completely and install and tighten radiator cap.


Side screen must be removed for cleaning to avoid contaminating or damaging the radiator.

Keep engine compartment clean. Wipe off filter base on engine. Using incorrect coolant mixture can damage the radiator: Failure to check the oil level regularly could lead to serious engine problems if oil level is low: Install new filter by turning it to the right clockwise until rubber gasket contacts filter base. Damage may occur to cast aluminum parts. Remove radiator drain plug or disconnect lower radiator hose D.

Do not open canister unless required for scheduled service. This mixture will provide freeze protection to degrees C degrees F. Some oil will remain in engine after draining.

John Deere Operator Manual | Parts & Services | John Deere US

Certain geographical areas may require lower temperature protection. Install and tighten radiator cap. Then remove the cap. Pull off the differential lock lever knob.

John Deere 6×4 Gator Technical Service Manual CD TMCD | eBay

Park the vehicle safely. Allow engine to cool and suction back any needed coolant from overflow reservoir. If using concentrate, mix approximately 50 percent antifreeze with 50 percent distilled or deionized water before adding to cooling system. Turn radiator cap slowly to the stop to release system pressure.


Operator’s Manuals for John Deere equipment

Make sure air intake tube A is free from obstructions. Check instruction molded into canister cover for proper installation. Tighten filter an additional one-half turn. Coolant cannot be drawn into cooling system if suction hose is installed wrong.

If engine is hard to start or runs rough, check the troubleshooting section dervice this manual.

John Deere 4×2 / 6×4 Gator Workshop Repair Manual on CD

Loosen engine block drain screws E on right side of engine. Visually check dust unloading valve A. The vehicle requires large volumes of air to keep cool. Use oil viscosity based on the expected air temperature range during the period between oil changes. Filter element must be checked more frequently if operating in dusty conditions. Install drain plug 4×2 or close drain petcock and remove hose serfice drain hole in floor plate 6×4. Follow the directions on the container for correct mixture ratio.